Epoxy Flooring in Zapata, TX

Epoxy flooring in Zapata covers a wider mix of jobs than you might expect for a town of about 5,400 people. Zapata is the county seat, it sits on Falcon International Reservoir, and its economy runs on oil and gas, ranching, trade and tourism. So in one week we might see a garage that holds a bass boat, a covered patio facing the water, and a service bay where field trucks come in caked with mud.

A town rebuilt on higher ground

Zapata was moved to higher ground in 1953, before Falcon Dam was finished, and the original town center is now under the lake. That history shapes the floors. Most homes and businesses here were built after the move, so the oldest concrete in town is roughly seventy years old and much of it is far younger. Mid-century slabs often have patched cracks, old paint or tile adhesive from earlier owners. We grind all of it off and repair the surface before we start a coating.

Boats, trailers and lake gear

Wikipedia notes that Falcon Reservoir is known for bass fishing, and the reservoir's own page lists largemouth bass, crappie and catfish. A boat garage floor gets wet hulls, dripping trailers, fuel and fishing gear. For these floors we suggest:

• Epoxy flake floors with a polyaspartic topcoat, which hide water spots and give grip on a wet floor
• Chemical-resistant topcoats near the spot where outboards and fuel cans sit
• A sealed edge at the door line where water runs in off the trailer

Get a Free Estimate

Winter Texans and seasonal homes

Between November and April many Winter Texans stay in the area, mostly in travel trailers. Seasonal owners often want work done while they are away or right before they arrive. Concrete pads under RVs, covered parking and small storage buildings can all take a coating. A UV-stable top matters on any slab under a carport or awning, because low winter sun still reaches under the roof line. If you are not in town, we can walk the slab with you by video and send a written estimate.

Garages that face the sun

Many Zapata garages sit with the door open for hours while people load the boat or work on a truck. Sunlight that reaches the floor will yellow a plain epoxy over time. We finish every garage that sees daylight with a UV-stable polyaspartic or urethane topcoat, so the floor near the door matches the floor at the back wall years later.

Oil and gas shops

Natural gas and oil are among the county's leading employers. Shop floors that serve that work see heavy trucks, drilling mud and lubricants. We use thicker 100% solids epoxy here with a textured, chemical-resistant topcoat, and we fill and seal control joints so fluids do not sit in the cuts.

Floors that switch between seasons

Many Zapata homes see heavy use in the cooler months and lighter use in summer. A garage that holds a boat in spring may hold patio furniture and a second vehicle by fall. We pick a system for the hardest use the floor will see, which is usually the boat or the work truck, so it holds up the rest of the year without a second job.

Heat even in January

Zapata holds the all-time U.S. January high of 98°F, set January 5, 1997, and its record high is 116°F. Our installers plan around that whatever the calendar says. We read slab temperature on every job, including the ones in winter.